Elta 2309 Especificações

Installation -Electrical InformationWater-Cooled CenTraVac™With CH530X39640647040 CVHE-SVN03D-EN

PFCC10 CVHE-SVN03D-ENRule 1Simultaneously disconnect capacitors and load from line power. If the capacitors are not switched off-line when the load is

PFCCCVHE-SVN03D-EN 11Recommended Procedures for Discharging CapacitorsPrior to performing any service on energized equipment, the proper Lockout-Tagou

12 CVHE-SVN03D-ENUnit Mounted StarterInterconnecting WiringTypical equipment room conduit layouts with and without unit mounted starters are shown in

CVHE-SVN03D-EN 13Remote StarterFigure 5. Typical equipment room layout with remote-mounted Wye-Delta starterNotes:1. Refer to the unit field connectio

Remote Starter14 CVHE-SVN03D-ENStarter to Motor (Remote-Mounted Starters Only)Ground Wire Terminal LugsGround wire lugs are provided in the motor term

Remote StarterCVHE-SVN03D-EN 15CAUTIONComponent Damage!Remove all debris from inside the starter panel. Failure to do so may result in an electrical s

16 CVHE-SVN03D-ENMotor LugsFigure 6. Terminal stud, clamp and lug assemblyMid Voltage RXL RATR RPIR CXL CATR CPIRBellevilleWasher3/8" BoltMotorTe

CVHE-SVN03D-EN 17Field Control Panel Signal WiringTable 5.Standard Control Circuits: UCP Control Wiring (120 VAC)Unit Control TerminationsIncluded inF

Field Control Panel Signal Wiring18 CVHE-SVN03D-ENUCP Electrical SpecificationsFollowing is a requirements list for the UCP in the control panel:Note

Field Control Panel Signal WiringCVHE-SVN03D-EN 19The sensor probe lead wire between the sensor probe and the module can be separated by cutting the t

Warnings andCautions© 2005 American Standard All rights reserved CVHE-SVN03D-ENNotice that warnings and cautions appear at appropriate intervals throu

Field Control Panel Signal Wiring20 CVHE-SVN03D-ENControl Panel Internally mounted devicesFor visual identification Internal Control Panel mounted dev

Field Control Panel Signal WiringCVHE-SVN03D-EN 21Figure 8. Control panel components layout

Field Control Panel Signal Wiring22 CVHE-SVN03D-ENFigure 9. Illustrated communication/control network to chiller with CH530

CVHE-SVN03D-EN 23WiringDrawingsSchematic Wiring DrawingsThe following pages consist of typical wiring drawings for an CVHE, CVHF or CVHG chiller. Howe

Wiring Drawings24 CVHE-SVN03D-EN2309-7945Unit mounted wye-delta starter with optional GRDF and PFCC, without optional CPTR

Wiring DrawingsCVHE-SVN03D-EN 252309-7945 (Con’t)Unit mounted wye-delta starter with optional GRDF and PFCC, without optional CPTR

Wiring Drawings26 CVHE-SVN03D-EN2309-7962Unit mounted solid state starter with optional GRDF and PFCC, without optional CPTR

Wiring DrawingsCVHE-SVN03D-EN 272309-7962 (Con’t)Unit mounted solid state starter with optional GRDF and PFCC, without optional CPTR

Wiring Drawings28 CVHE-SVN03D-EN2309-7996Unit mounted across the line starter standard 3-lead motor connection with optional GRDF and PFCC, without op

Wiring DrawingsCVHE-SVN03D-EN 292309-7996 (Con’t)Unit mounted across the line starter standard 3-lead motor connection with optional GRDF and PFCC, wi

CVHE-SVN03D-EN 3ContentsWarnings and Cautions ...2General Information...

Wiring Drawings30 CVHE-SVN03D-EN2309-8033Unit mounted adaptive frequency drive 405-608A LiquiFlo 2, Frame 3

Wiring DrawingsCVHE-SVN03D-EN 312309-8033 (Con’t)Unit mounted adaptive frequency drive 405-608A LiquiFlo 2, Frame 3

Wiring Drawings32 CVHE-SVN03D-EN2309-8034Unit mounted adaptive frequency drive 810-1210A LiquiFlo 2, Frame 4

Wiring DrawingsCVHE-SVN03D-EN 332309-8034 (Con’t)Unit mounted adaptive frequency drive 810-1210A LiquiFlo 2, Frame 4

Wiring Drawings34 CVHE-SVN03D-EN2309-7974Unit mounted auto-transformer starter standard 3-lead motor connection with optional GRDF and PFCC, without o

Wiring DrawingsCVHE-SVN03D-EN 352309-7974 (Con’t)Unit mounted auto-transformer starter standard 3-lead motor connection with optional GRDF and PFCC, w

Wiring Drawings36 CVHE-SVN03D-EN2309-7985Unit mounted primary reactor starter standard 3-lead motor connection with optional GRDF and PFCC, without op

Wiring DrawingsCVHE-SVN03D-EN 372309-7985 (Con’t)Unit mounted primary reactor starter standard 3-lead motor connection with optional GRDF and PFCC, wi

Wiring Drawings38 CVHE-SVN03D-EN2309-7952Remote mounted wye-delta starter with optional GRDF and PFCC, without optional CPTR

Wiring DrawingsCVHE-SVN03D-EN 392309-7952 (Con’t)Remote mounted wye-delta starter with optional GRDF and PFCC, without optional CPTR

CVHE-SVN03D-EN 4General InformationGeneral RequirementsNote: Unit-mounted starters are available as an option on most CVHE, CVHF, and CVHG units with

Wiring Drawings40 CVHE-SVN03D-EN2309-7960Remote mounted solid state starter with optional GRDF and PFCC, without optional CPTR

Wiring DrawingsCVHE-SVN03D-EN 412309-7960 (Con’t)Remote mounted solid state starter with optional GRDF and PFCC, without optional CPTR

Wiring Drawings42 CVHE-SVN03D-EN2309-7994Remote mounted across the line starter standard 3-lead motor connection with optional GRDF and PFCC, without

Wiring DrawingsCVHE-SVN03D-EN 432309-7994 (Con’t)Remote mounted across the line starter standard 3-lead motor connection with optional GRDF and PFCC,

Wiring Drawings44 CVHE-SVN03D-EN2309-7983Remote mounted primary reactor starter standard 3-lead motor connection with optional GRDF and PFCC, without

Wiring DrawingsCVHE-SVN03D-EN 452309-7983 (Con’t)Remote mounted primary reactor starter standard 3-lead motor connection with optional GRDF and PFCC,

Wiring Drawings46 CVHE-SVN03D-EN2309-7972Remote Mounted Auto-transformer Starter

Wiring DrawingsCVHE-SVN03D-EN 472309-7972 (Con’t)Remote Mounted Auto-transformer Starter

Wiring Drawings48 CVHE-SVN03D-EN2309-7998Customer supplied wye-delta starter standard chiller without optional CPTR

Wiring DrawingsCVHE-SVN03D-EN 492309-7998 (Con’t)Customer supplied wye-delta starter standard chiller without optional CPTR

CVHE-SVN03D-EN 5Trane SuppliedRemote StarterTable 1. CVHE, CVHF, and CVHG standard remote starter field wiring requirementsPower supply wiring (to Sta

Wiring Drawings50 CVHE-SVN03D-EN2309-8012Customer supplied auto-transformer or primary reactor starter standard 3-lead motor connection without option

Wiring DrawingsCVHE-SVN03D-EN 512309-8012 (Con’t)Customer supplied auto-transformer or primary reactor starter standard 3-lead motor connection withou

Wiring Drawings52 CVHE-SVN03D-EN2309-8022Customer supplied across the line starter standard 3-lead motor connection without optional CPTR

Wiring DrawingsCVHE-SVN03D-EN 532309-8022 (Con’t)Customer supplied across the line starter standard 3-lead motor connection without optional CPTR

Wiring Drawings54 CVHE-SVN03D-EN2309-8002Customer supplied solid state starter standard chiller without optional CPTR

Wiring DrawingsCVHE-SVN03D-EN 552309-8002 (Con’t)Customer supplied solid state starter standard chiller without optional CPTR

Wiring Drawings56 CVHE-SVN03D-EN2309-8041Factory installed standard, NEMA 4 or industrial earthwise purge

Wiring DrawingsCVHE-SVN03D-EN 572309-8041 (Con’t)Factory installed standard, NEMA 4 or industrial earthwise purge

Wiring Drawings58 CVHE-SVN03D-EN2309-8036Unit controls without optional CPTR

Wiring DrawingsCVHE-SVN03D-EN 592309-8036 (Con’t)Unit controls without optional CPTR

6 CVHE-SVN03D-ENCustomer SuppliedRemote StarterTable 2. CVHE, CVHF, and CVHG standard customer supplied remote field wiring requirementsPower supply w

Wiring Drawings60 CVHE-SVN03D-EN2309-8039System controls with optional HGBP or FRCL

Wiring DrawingsCVHE-SVN03D-EN 612309-8039 (Con’t)System controls with optional HGBP or FRCL

Wiring Drawings62 CVHE-SVN03D-EN2309-8043Optional controls

Wiring DrawingsCVHE-SVN03D-EN 632309-8043 (Con’t)Optional controls

Wiring Drawings64 CVHE-SVN03D-EN2309-2178)Main unit control panel used with all low and medium voltage starters

Wiring DrawingsCVHE-SVN03D-EN 652309-2178 (Con’t)Main unit control panel used with all low and medium voltage starters

Wiring Drawings66 CVHE-SVN03D-EN2309-2169Trane supplied Wye-delta or solid state starter

Wiring DrawingsCVHE-SVN03D-EN 672309-2169 (Con’t)Trane supplied Wye-delta or solid state starter

Wiring Drawings68 CVHE-SVN03D-EN2309-2171Trane supplied auto-transformer, primary reactor or across the line starter

Wiring DrawingsCVHE-SVN03D-EN 692309-2171 (Con’t)Trane supplied auto-transformer, primary reactor or across the line starter

CVHE-SVN03D-EN 7Customer SuppliedRemote StarterTable 3. Current transformer and potential transformer wire sizing tables for customer supplied starter

Wiring Drawings70 CVHE-SVN03D-EN2309-2173Customer supplied wye-delta or solid state starter

Wiring DrawingsCVHE-SVN03D-EN 712309-2173 (Con’t)Customer supplied wye-delta or solid state starter

Wiring Drawings72 CVHE-SVN03D-EN2309-2175Customer supplied auto-transformer, primary reactor or across the line starter

Wiring DrawingsCVHE-SVN03D-EN 732309-2175 (Con’t)Customer supplied auto-transformer, primary reactor or across the line starter

Wiring Drawings74 CVHE-SVN03D-EN2309-2177Trane supplied LiquiFlo 2 adaptive frequency drive

Wiring DrawingsCVHE-SVN03D-EN 752309-2177 (Con’t)Trane supplied LiquiFlo 2 adaptive frequency drive

Wiring Drawings76 CVHE-SVN03D-EN2309-2181Unit mounted controls used with all starters and adaptive frequency drives

Wiring DrawingsCVHE-SVN03D-EN 772309-2181 (Con’t)Unit mounted controls used with all starters and adaptive frequency drives

Wiring Drawings78 CVHE-SVN03D-EN2309-2182CH530 schematic wiring diagram device descriptions

Wiring DrawingsCVHE-SVN03D-EN 792309-2182 (Con’t)CH530 schematic wiring diagram device descriptions

8 CVHE-SVN03D-ENPowerSupplyPower Supply WiringTo assure that power supply wiring to the starter panel is properly installed and connected, review and

Tr a n eA business of American Standard Companieswww.trane.comFor more information, contact your local Trane office or e-mail us at [email protected]

CVHE-SVN03D-EN 9PFCCOptional PFCCsPower factor correction capacitors (PFCCs) are designed to provide power factor correction for the compressor motor.